HomeMy WebLinkAbout05070097 Pool Plans,,/
/
/
0
0
- 4-0
- 4:' o +-
'"'( ,
~ o 0
-0
0 o
0
' i
SPECIFICATIONS / MODEL DESCRIPTIONS
Shell
Posi. LokTM
Lalch
Lower
7.4~
FIGURE '1 - Dimensions in inches (mm}
Service
Heighl
32.75"
[832 mm]
{584 mm)
Table I - Filter Specifications
PLM100 PLM150
FiJterArea sq ~t. (m:) 100(9.31 150(141
Max. Rated Flow GPM (LPM) 75(2891 1 t 2{424]
Recommended Flow GPM (LPM)* 5011891 50(1891
Max. Operating Pressure PSI (kPa~ 50(3451 50{3451
Max. Continuous Water
Temperature F(C) t 100(43°) i 10°(43~
* For best water clarity and filter cycle length, restrict
water flow to 50 GPM (189 LPM).
(97)
(69)
~8
(55)
8
(411
(141
10 20 40
60 80 100 120
(38) (76) (1511 (227) [303) (378) (454I
Flow in Gallons Per Minule (LPM)
FIGURE 2 - Pressure Drop Cbrve
Model Descriptions:
PLM100JWAE-03 PLM100JWAF-03
PLM150JWAE-03 PLM150JWAF-03
Hoses, Adapters, Clamps, and U.S.A. Spec. Motor
__ (includes 3'Cord w/straigh PlugJ __
PLM100JWAE~04 PLM100JWAF-04
PLM150]WAE-04 PLM150JWAF-04
Adapters, Clamps, and U.S.A, Spec. Motor
__ (Includes 3' Cord w/Straight PJu)
PLM100JWAE-06 PLM100JWAF-06
PLM150JWAE-06 PLM150JWAF-06
Adapters, Clamps, and Canadian Spec. Motor
(In [udes 25' Cord w/Straight Plug) .
PLM100JWAE-12 PLM100JWAF-12
PLM150JWAE-12 PLM150JWAF-12
Adapters, Clamps, and U,S.A. Soec. Motor
(includes 3' Cord w/Twist-Lok Plug)
Hazardous voltage.
Can shock, burn.
or cause death.
Disconnect power
before working
on pump or motor.
ELECTRICAL
,~ Risk of electrica shock. Plug pump into a grounded, GFCI-proteded 115
Volt circuit only. Incorrect voltage can cause fire or seriously damage
motor and voids warranty. Protect cord from water and physical damage.
GFCI tripping indicates an electrical problem. If GFCI trips and will not
~ reset ha~"e a qualified electrician inspect and repalr e ectr ca system.
~ Risk of electrical shock. Unplug motor before servicing or re-
pairing pump or motor.
Wiring:
Install a Ground Fault Circuit Interrupter (GFCI) in circuit; it will sense a short
circuit to ground and disconnect power before t becomes dangerous to pool or
spa users. For size of GFCI required and test procedures for GFCI, see manufac-
turer's instructions.
In case of power outage, check GFCI for tripping (which will prevent normal
water circulation); reset if necessary.
Do not connect any other lights or appliances to the same Circuit.
Match circuit breaker size to Table I1 below.
,, Do not modify cord plu~, or receptacle. If an existing circuit must be used
an~ the receptacle and plug do not match exactly, consult a licensed electri-
clan.
· Do not use an extension or drop cord with this system; it could cause a fire
hazard or Iow voltage problems. Wel cords cause shock hazards. Extension
cords can easilf become cut or frayed and dangerous when placed across
yard areas or walkways
Voltage:
Voltage at motor must be not more than 10% above or below motor name-
plate rated vo rage or motor may overheat causing overload tripping and re-
duced component life. If voltage is less than 90% or more than 110% of rated
voltage when motor s runn ng at full load consult ~ower company.
Table U-Recommended Fusing Data, 115 Volt 60 Hz Motors.
Model Motor Max Load Branch Circuit Breaker
No. H.P. Amps Rating (Amps)
JWPA5E7L-2A1. -2A2 I 11.2 15
7290-J100-2 I 13.2 20
JWPA5F7L-2A1, -2A2. 1.1/2 16.0 20
7290-J150-2 1-1/2 13.5 20
~CE Values given are for pum~y. Do not put any other accessories on
this circuit.
I HP Filter system with
Model No. suffix:
-03, -04, or -06
1-1/2 HP Filter system
with Model No. suffix:
-03, -04, or -06
All Filter SyStems With
Model No~ suffix:
-12
1-1/2 HP Pumps with
-2A2 suffix use 20 amp
straight outlet, a~:~ove.
! HP Puml~s with .2A2
suffix and Canadian Spec
Pumps use 15-amp straight
outlet, above.
All Pumps with
*2A~ suffix use 20-amp
twist-lock outlet, above.
FIGURE 3 - Plug configurations
6
3 4
Description
Cap and Cord Ass'y
Toggle Switch
Toggle Switch Boot
Baffle Ring
Motor
Flinger
Motor Cover
Sea] Plate
Shaft Seal
Impelle~
"0" Ring
Front Plate
Plain Washer
Lock Washer
Cao Screw
Trap Lid
Trap Lid Gasket
Trap Basket
Trap Body
Drain Plug w/O-Ring
Cap Screw
Lock Washer
Plain Washer
Trap Outlet Gaskel
Mounting Foot
Nameplate
Decal - GFCt Required
Tag- Do Not Use Pipe Dope
Tag - Electrical, priming
/B
7
Part
Number
37337-00BS
Chart at Right
16920-0511
32800-0107
t 7290-0004
Chart at Right
C69-2
17190-0021
1730t -0150
U9-358SS
Chart at Right
U9-357
C101-272P
U43-6055
U43-10SS
U30-87355
C3-139P1
U9-229
C108-33P
C153-53P
U 178-920P
U30-6455
U43-11SS
U43-4155
C20-123
17190-0023
32155-4073
U27-558
] 002-0002
1 O02-0004
REPAIR PARTS LIST -- 17290
See Pump nameplate for Pun
for Filter System wi
9 16
15
11
12
21
23
22
Parts are common [o all models listed except as noted;
Key Nos. 6, Motor; and 11, Impeller, are li~ted below.
~ MotorNo. '"] Impeller No.
Model No. HP (Key No. 6) _ (Key No. 11 ) _
- sv/6on J J
s _
!L?°/'
~~ 7 ~ ~0-O063-S
Tra_.~over/"O" Ring. Kit (5" Tra~
Kit includ"e~c3-139P'1 Trap Cover and U9-229 "0" Ring.~
ParLs-Pak No. PP2075.
16